2022-2025 Genesis GV70 & Electrified GV70 Engine Compartment Side Panels: Cracks, Rattles, and Replacement
Your complete guide to diagnosing and replacing the left and right engine bay trim panels that fit both gasoline and electric GV70 models.
- These side panels are identical for both the 2022-2025 gasoline GV70 and the 2023-2024 Electrified GV70.
- The parts are sold individually: 861A0-AR000 for the left (driver) side and 861B0-AR000 for the right (passenger) side.
- When buying a used panel, the most critical inspection point is the integrity of the plastic mounting tabs and clips.
- There are no known recalls or TSBs for this specific part; failure is due to physical damage or wear, not a design defect.
Symptoms of a Failing Engine Compartment Panel
Since this is a cosmetic and protective plastic part, failure is related to physical damage rather than mechanical or electrical issues. You will not see any check engine lights or receive diagnostic trouble codes for this part. Symptoms are typically straightforward:
- Rattling or Buzzing Noises: The most common symptom is noise from under the hood, especially at idle or over rough roads. This usually happens when a mounting clip breaks or the panel becomes loose, allowing it to vibrate against the body or other components.
- Visible Cracks or Warping: Over time, exposure to engine heat (on gas models) and the elements can cause the plastic to become brittle and crack. Warping can also occur, preventing the panel from sitting flush.
- Panel is Loose or Missing: The panels can be dislodged during service if not reinstalled correctly, or clips can fail from age. A missing panel exposes sensitive components to debris and creates an unfinished look in the engine bay.
Known Issues, Recalls, and Technical Service Bulletins (TSBs)
As of mid-2024, there are no recalls or Technical Service Bulletins (TSBs) specifically related to the engine compartment side panels for either the Genesis GV70 or the Electrified GV70. While these vehicles have had recalls for other issues like seat belt pretensioners, fuel pumps, and software updates, the side panels themselves have not been identified as a problem part by the manufacturer.
Pro Tip: Some 2022-2023 GV70 models were subject to TSB #24-BD-008G-1 for water leaking into the cabin due to clogged sunroof drain hoses. While unrelated to the side panels, the repair involves accessing areas near the cowl, so it's worth being aware of if you are working in this part of the vehicle.
Vehicle and Part-Specific Details
Gas vs. Electrified GV70: Do They Use the Same Part?
Yes, both the gasoline-powered GV70 and the Electrified GV70 use the exact same engine compartment side panels. Although one vehicle has an internal combustion engine and the other has a front motor and a 'frunk' (front trunk), they are built on the same platform. The mounting points on the vehicle's body where these panels attach are identical. This makes sourcing a used part simple, as you can get one from either a gas or electric model and it will fit perfectly.
Buying a Used Engine Compartment Panel: What to Check
Buying a used OEM panel is often the most cost-effective option, as aftermarket replacements are generally not available. A used original part will fit perfectly, unlike potential aftermarket options. When inspecting a used panel, focus on its physical integrity.
- Inspect All Mounting Tabs: This is the most critical checkpoint. Carefully examine every tab, clip receiver, and hole for cracks or breaks. A panel with even one broken mounting point may not sit securely and could rattle or come loose.
- Check for Cracks and Stress Marks: Look over the entire surface, especially around the edges and corners, for any cracks. Pay close attention to the areas around the mounting holes, as this is where stress is concentrated.
- Look for Heat Damage or Warping: On panels from a gasoline GV70, check for any signs of warping or discoloration from proximity to hot engine components. The plastic should be flat and uniform.
- Verify Part Numbers: While not strictly necessary if you know the donor vehicle, matching the part number is the best way to guarantee a perfect fit. The left and right sides have different numbers.
Replacement Cost and Part Numbers
Expect to save significantly by choosing a quality used OEM part over a new one from the dealer. Shop labor, if you choose not to do it yourself, should be minimal.
| Part Source | Estimated Cost (for a pair) |
|---|---|
| New OEM (Dealer) | $160 - $240 |
| Used OEM (Recycled) | $80 - $150 |
| New Aftermarket | Not Generally Available |
| Shop Labor | $45 - $75 |
OEM Part Numbers
These panels are sold individually. Always confirm the part number for your specific needs.
| Position | Part Number | Common Name |
|---|---|---|
| Left (Driver Side) | 861A0-AR000 / 861A0AR000 | Cover Assembly Engine Room, LH |
| Right (Passenger Side) | 861B0-AR000 / 861B0AR000 | Cover Assembly Engine Room, RH |
Installation Guide
Difficulty: 1 out of 5 (Very Easy)
Estimated Time: 10 minutes
Replacing these panels is a simple DIY task that requires no special tools.
- Open the Hood: Secure the hood in the open position.
- Locate the Panel: Identify the panel to be replaced on the left or right side of the compartment.
- Remove Fasteners (if any): Look for any plastic push-pin clips holding the panel in place. If present, use a trim removal tool or a small flathead screwdriver to gently pry the center pin up and then remove the entire clip.
- Unclip the Panel: Grasp the edge of the panel and pull upward firmly and evenly. It is held in place by several pressure clips that will release as you pull.
- Install the New Panel: Align the clips on the new panel with the corresponding holes in the vehicle's frame. Press down firmly until you hear and feel each clip snap into place.
- Reinstall Fasteners: If you removed any push-pin clips, reinstall them by pushing the base in first, followed by the center pin to lock it.
Frequently Asked Questions (FAQ)
Do these panels fit both the gas and electric GV70?
Yes, the 2022-2025 Genesis GV70 (gas) and the 2023-2024 Genesis Electrified GV70 use the exact same side panels with the same part numbers.
Are the left and right panels sold together as a set?
No, dealers sell the left (861A0-AR000) and right (861B0-AR000) panels as separate parts. However, some used parts sellers on sites like eBay may offer them as a pair.
Is a missing engine compartment panel a serious problem?
It is not a critical safety issue, and the vehicle is perfectly drivable without one or both panels. However, a missing panel will allow more dirt, water, and road grime to accumulate on electrical connections, fluid caps, and the chassis, which could lead to other issues over time.
My panel is secure, but I still hear a rattle. What else could it be?
Rattles in the GV70 engine bay can also be caused by loose exhaust heat shields, worn suspension components like sway bar links, or issues with the braking system. If the side panels are secure, these other areas should be inspected.
Technical Specifications
OEM Part Numbers: 861A0-AR000 861A0AR000 861B0-AR000 861B0AR000
Material: Molded plastic. This is a set of two distinct parts for the left and right sides.
We Have This Part in Stock
The information in this article is provided for general reference and educational purposes only. Vehicle specifications, procedures, and part compatibility can vary by production date, trim level, and region. Always consult your vehicle's factory service manual and verify part numbers before purchasing or performing repairs. Safety-critical components such as airbags, seat belts, and braking systems should be installed by a qualified professional.
- Genesis GV70:
- Genesis Electrified GV70:
- 🛍️ Shop This Part
- Symptoms of a Failing Engine Compartment Panel
- Known Issues, Recalls, and Technical Service Bulletins (TSBs)
- Vehicle and Part-Specific Details
- Gas vs. Electrified GV70: Do They Use the Same Part?
- Buying a Used Engine Compartment Panel: What to Check
- Replacement Cost and Part Numbers
- OEM Part Numbers
- Installation Guide
- Frequently Asked Questions (FAQ)
- 🎟️ Get 5% Off